NHTSA lists 3 safety recalls for the 2019 Chevrolet Silverado 4500. The newest, from November 6, 2025, covers the service brakes. Not every Chevrolet Silverado 4500 of this year is affected: check your VIN to see whether yours is, and whether the free repair has been done.
Park outside. One recall says affected vehicles should be parked outside, away from buildings, until they're repaired, because of a fire risk.
3 recalls, newest first
RecallNovember 6, 2025
Service brakes, hydraulic › power assist
General Motors, LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. These vehicles were remedied under NHTSA Recall 25V390 with a brake jumper wire harness that was assembled without protective tape. A wiring harness that is missing protective tape can allow the wires to become damaged.
Risk: Damaged brake jumper wires can result in power brake assist failure, increasing the risk of a crash.
Fix: Dealers will remove the installed wire harness, apply protective tape, and reinstall the wire harness, free of charge. Owner notification letters are planned to be mailed December 22, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N252531990. Vehicles in this recall were previously repaired under 25V390 and will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 6, 2025.
Service brakes, hydraulic › brake fluid low warning › switch/sensor/float
General Motors (GM) is recalling certain 2019-2024 Chevrolet Silverado Medium Duty 4500HD, 5500HD, and 6500HD vehicles. The brake pressure sensor assembly may leak brake fluid into the brake pressure switch and cause a short circuit.
Risk: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.
Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch wire harness, free of charge. Owner notification letters were mailed September 11, 2025. Owners may contact GM customer assistance number at 1-866-467-9700. GM's number for this recall is N242482680. Vehicles in this recall that were previously repaired under 23V266 will need to have the new remedy completed.
General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.
Risk: A short-circuit may damage the engine components and increase the risk of fire.
Fix: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Enter your 17-character VIN on NHTSA's site to see which of these recalls apply to your car and whether they've been repaired. Repairs are free at any Chevrolet dealer.
Recalls come from the National Highway Traffic Safety Administration's recall database, with the list of models updated October 7, 2026. A recall applies to some vehicles of a model year, not always all of them: your VIN tells you whether yours is included and if the free repair has been done.